Where is thermostat in Audi A4?
The thermostat on the Audi A4 is locating in located below the intake manifold and behind the alternator. To replace the thermostat you will need to drain the coolant and move the lock carrier to the service position.
How do you remove an Audi A4 thermostat?
- Step 1 – Remove serpentine belt. Use your 17mm wrench to push the tensioner down, this will allow the belt to come loose.
- Step 2 – Remove the alternator.
- Step 3 – Remove radiator hose.
- Step 4 – Lower radiator hose.
- Step 5 – Remove coolant lines.
- Step 6 – Remove thermostat.
- Step 7 – Install new thermostat.
Where is the thermostat on a 2001 Audi A4?
on the 2.8, the thermostat is located behind the water pump and usually done when doing the timing belt job, since it needs to be removed to get to it and the front of the car needs to come off.
How do you know if the thermostat in your car is bad?
One of the first things you will notice is the temperature gauge is higher than normal. It may even start to fluctuate frequently. If you notice the gauge is hovering ¾ of the way from the top, then your thermostat is experiencing damage in the form of overheating. This can soon lead to your engine and car overheating.
How much is a thermostat for Audi A4?
Audi A4 Thermostat Replacement Cost Estimate. Labor costs are estimated between $259 and $326 while parts are priced between $380 and $383. This range is based on the number and age of Audi A4’s on the road.
What’s the Audi A4 thermostat location?
The thermostat in the Audi A4 is sealed in the housing and cannot be replaced separately. The thermostat on the Audi A4 is locating in located below the intake manifold and behind the alternator.
When should I replace the thermostat in my car?
Replace older hoses. The thermostat helps control the engines temperature. If your car is running too hot and there is the proper amount of coolant in the car and it is not leaking, or your car is taking a long time to warm up, there is a very good chance your thermostat is bad and needs to be replaced.
How do you know if your thermostat is bad?
The thermostat helps control the engines temperature. If your car is running too hot and there is the proper amount of coolant in the car and it is not leaking, or your car is taking a long time to warm up, there is a very good chance your thermostat is bad and needs to be replaced.
What should I check before installing a new thermostat?
Figure 13 Before installing the new thermostat and housing make sure to check the mounting area to insure it is clean and level. Most important is to make sure the old O-ring gasket is not still in the block. Installation is the reverse of removal. Do NOT forget to replace the coolant.